PERMATEX INDUSTRIAL CORPORATION 07/02/97 ROCKY HILL, CONNECTICUT 06067 TELEPHONE: (860) 571-5100 MATERIAL SAFETY DATA SHEET Page 01 of 04 Permatex(R) Hydraulic Jack Oil 80055 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Product Name: Permatex(R) Hydraulic Jack Oil Item No.: 80055 Part No.: 78F Product Type: Hydraulic Fluid 2. COMPOSITION, INFORMATION ON INGREDIENTS Ingredients CAS No. % Mineral oil 64742-52-5 95-100 Polymethacrylate dispersion Proprietary 1-3 Rust inhibitor Proprietary 0.1-1 Surfactant Proprietary 0.01-0.1 Ingredients which have exposure limits Exposure Limits (TWA) ACGIH OSHA OTHER Ingredients (TLV) (PEL) Mineral oil 5 mg/m3 mist 5 mg/m3 mist 5 mg/m3 mist Exposure Limits (STEL) ACGIH OSHA Ingredients (TLV) (PEL) Mineral oil 10 mg/m3 mist None 3. HAZARDS IDENTIFICATION Toxicity: Skin and eye irritant. Primary Routes of Entry: Skin, ingestion, inhalation Signs and symptoms of Exposure: Prolonged exposure may cause dermatitis. Breathing of mist or vapor may cause irritation of the pulmonary tract or aspiration pneumonia. Existing Conditions Aggravated by Exposure: None known Literature Referenced Carcinogen Ingredients Target Organ and Other Health Effects NTP IARC OSHA Mineral oil IRR NO NO NO Polymethacrylate dispersion No Data NO NO NO Rust inhibitor No Data NO NO NO Surfactant No Data NO NO NO ------------------------------------------------------------------------------- PERMATEX INDUSTRIAL CORPORATION 07/02/97 ROCKY HILL, CONNECTICUT 06067 TELEPHONE: (860) 571-5100 MATERIAL SAFETY DATA SHEET Page 02 of 04 Product Name: Permatex(R) Hydraulic Jack Oil Item No.: 80055 3. HAZARDS IDENTIFICATION (continued) Abbreviations IRR Irritant 4. FIRST AID MEASURES Ingestion: Do not induce vomiting. Keep individual calm. Obtain medical attention. Inhalation: Not likely to occur except as mist. Remove to fresh air. If symptoms persist, obtain medical attention. Skin Contact: Wash with soap and water. If irritation persists, consult a physician. Eye Contact: Flush with water for at least fifteen minutes. Obtain medical attention. 5. FIRE FIGHTING MEASURES Flash Point: More than 200°F Method: Open cup Recommended Extinguishing Agents: Carbon dioxide, foam, dry chemical Hazardous Products formed by Fire or Thermal Decomp Irritating organic vapors Unusual Fire or Explosion Hazards: None Explosive Limits: (% by volume in air)Lower Not available (% by volume in air)Upper Not available 6. ACCIDENTAL RELEASE MEASURES Steps to be taken in case of spill or leak: Contain spill. Soak up in an inert absorbent. Store in a closed container until disposal. Clean up residue with soap and water. 7. HANDLING AND STORAGE Safe Storage: Keep away from flames, sparks, or hot surfaces. (Contact Loctite Customer Service 1-800-243-4874 for shelf Life information) Handling: Avoid skin contact. Keep away from eyes. Avoid prolonged breathing of vapors. PERMATEX INDUSTRIAL CORPORATION 07/02/97 ROCKY HILL, CONNECTICUT 06067 TELEPHONE: (860) 571-5100 MATERIAL SAFETY DATA SHEET Page 03 of 04 Product Name: Permatex(R) Hydraulic Jack Oil Item No.: 80055 8. EXPOSURE CONTROLS, PERSONAL PROTECTION Eyes: Safety glasses or goggles. Skin: Neoprene or plastic gloves. Ventilation: Sufficient to maintain vapor concentration below TLV. See Section 2 for Exposure Limits. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance: Amber liquid Odor: Mild petroleum Boiling Point: More than 500°F pH: Does not apply Solubility in Water: Negligible Specific Gravity 0.905 at 60°F Volatile Organic Compound (EPA Method 24) 21.6% Vapor Pressure: Less than 5 mm Vapor Density: Not available Evaporation Rate (Ether = 1) Not available 10. STABILITY AND REACTIVITY Stability: Stable Hazardous Polymerization: Will not occur Incompatibility: Strong oxidizers. Conditions to Avoid: Not available Hazardous Decomposition Products (non-thermal): None 11. TOXICOLOGICAL INFORMATION See Section 3. 12. ECOLOGICAL INFORMATION No data available 13. DISPOSAL CONSIDERATIONS Recommended methods of disposal: Incinerate following EPA and local regulations. EPA Hazardous Waste Number NH - Not a RCRA Hazardous Waste Material PERMATEX INDUSTRIAL CORPORATION 07/02/97 ROCKY HILL, CONNECTICUT 06067 TELEPHONE: (860) 571-5100 MATERIAL SAFETY DATA SHEET Page 04 of 04 Product Name: Permatex(R) Hydraulic Jack Oil Item No.: 80055 14. TRANSPORTATION INFORMATION DOT (49 CFR 172) Domestic Ground Transport Proper Shipping Name: Unrestricted Hazard Class or Division: Unrestricted Identification Number: None Marine Pollutant: None IATA Proper Shipping Name: Unrestricted Class or Division: Unrestricted UN or ID Number: None 15. REGULATORY INFORMATION CA Proposition 65: WARNING: This product contains chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. 16. OTHER INFORMATION Estimated NFPA(R) Code: Health Hazard: 0 Fire Hazard: 1 Reactivity Hazard: 0 Specific Hazard: Does not apply Estimated HMIS(R) Code: Health Hazard: 0 Flammability Hazard: 1 Reactivity Hazards: 0 Personal Protection: See Section 8. NFPA is a registered trademark of the National Fire Protection Assn. HMIS is a registered trademark of the National Paint and Coatings Assn. Prepared By: Stephen Repetto Title: Research Chemist, Health and Safety Company: Loctite Corp., 1001 Tr Br Cr, Rocky Hill CT 06067 (24hr.) Phone: (860) 571-5100 Revision Date: January 22, 1996 Revision: 0019